Influence of dynamic characteristics of tractor hydrocylinders on its workership
DOI:
https://doi.org/10.31548/machenergy2019.03.145Keywords:
hydraulic cylinder, failure, radial response, efficiency, contact voltage, friction force, hydraulic pressure.Abstract
The theoretical analysis of influence of the power mode of the hydraulic cylinder on its efficiency is carried out. A fivefold increase in the value of the reaction from the side of the cap and the cylinder sleeve is determined, depending on the position of the piston of the hydraulic cylinder of the tractor's rear end. The main causes of the wear of the working surfaces of friction in the vertical plane are determined, which leads to the formation of the deflection of the hydraulic cylinder and, as a consequence, an increase in the rate of wear and loss of the resource.References
Dyachenko V. G. (2009). Theory of internal combustion engines: textbook. for universities. Kharkov: KHNADU, 340.
Ivanov R. V. (2010). Diagnosis of internal combustion engines by the parameter of the power of mechanical losses: abstract dis. Cand. tech. sciences. Volgograd, 40.
Zhdanovsky N. S. (2017). Thermodynamic analysis of compression end parameters at diesel start Power engineering. No. 8. 18-19.
Drobyshevsky Ch. V., Borovikov V. F., Fakhrutdinov A. G., Lazurko V. P. (2019). Evaluation of the thermodynamic parameters of the charge in starting conditions and the possibility of starting. Engine building. No. 11. 9-10.
Boldyrev I. V. (2014). Mathematical model of engine starting. Engine building. No. 6. 14-16.
Saraeva I. Yu. (2011). Investigation of the distribution law of a random value of compression. Automobile Transport. No. 29. 199-206.
Suranov G. I. (2012). Reduced wear on tractor engines during start-up. Moscow. Kolos, 143.
Ponizovsky A. Yu. (2010). Assessment of the technical condition of the cylinder-piston group of automotive diesel engines for various air flow rates at the inlet and outlet in the starting mode: abstract dis. Cand. tech. sciences. Novosibirsk, 111.
Pichugin A. I. (2011). Improving the efficiency of diagnosis of a cylinder-piston group of automobile engines by improving methods and means of recognizing its condition. Abstract. dis. Cand. tech. Sciences. Saratov State Agrarian University. N.I. Vavilova. Saratov. 23.
Rogovskii Ivan, Titova Liudmyla, Novitskii Andriy, Rebenko Victor. (2019). Research of vibroacoustic diagnostics of fuel system of engines of combine harvesters. Proceedings of 18th International Scientific Conference "Engineering for rural development". Jelgava, Latvia, May 22-25, Latvia University of Agriculture. Faculty of Engineering. Vol. 18, 291-298. https://doi.org/10.22616/ERDev2019.18.N451
Downloads
Published
Issue
Section
License
Relationship between right holders and users shall be governed by the terms of the license Creative Commons Attribution – non-commercial – Distribution On Same Conditions 4.0 international (CC BY-NC-SA 4.0):https://creativecommons.org/licenses/by-nc-sa/4.0/deed.uk
Authors who publish with this journal agree to the following terms:
- Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
- Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
- Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).
