Визначення вологовмісту трансформаторного масла оптичними методами

Authors

  • О. І. Лобода

Abstract

UDC 621.313

DETERMINATION OF MOISTURE CONTENT OF TRANSFORMER

OIL BY OPTICAL METHODS

A. Loboda

The value of moisture is one of the important criteria of quality transformer oil and the criterion to determine the causes of deterioration of the dielectric properties of both the transformer was (TM) and solid isolation transformers. Therefore, an important issue is the analysis of existing methods for the quantitative determination of moisture content in TM.

The purpose of research - setting moisture on the optical properties of cobalt dichloride.

Materials and methods of research. The appearance of water in oil is a harbinger of accelerating failure of the power transformer and practice indicates inadequate supervision of electrical equipment or the aging of oil.

To determine the moisture content of transformer oil, the following methods: hidrodkaltsiyevyy method; Karl Fischer titration; gas chromatography; mass spectrometry; Photo-acoustic spectroscopy, etc.

Each of these methods has its advantages and disadvantages.

Results. Dihloryd cobalt - one of the most widely used optical sensors water. To test the sensitivity of the optical sensor of high quality experiment added anhydrous СоС12 in transformer oil is fresh and analyzed changes in the absorption spectra in visible and UV - ranges.

The absorption spectra of UV and visible range recorded at room temperature in the cell thickness of 10 mm spectrophotometer SF-46 in wavelength 190 ... 1100 nm at 600 nm / min at 1.0 nm slit width. The provisions of the lines in the spectra is given with an accuracy of ± 2,5 nm.

Found that a sharp change in absorbance near wavelength  400 nm is due to absorption and scattering radiation structural inhomogeneities (colloidal, micellar solid particles) in transformer oil. Dissolve powder in oil СоС12 increases the optical density at a wavelength in the range of 360 ... 490 nm, and an increase in moisture content increases the intensity of the absorption band.

However, the results suggest that optical method for determining the moisture content using СоС12 TM has a very high sensitivity and very promising for solving power energy.

Conclusions

The analysis of existing methods for determining the moisture content of transformer oil, offered the use of an optical method based on the dependence of the optical properties of cobalt dichloride moisture. The high sensitivity of the proposed method and the possibility of practical use.

References

Липштейн Р. А. Трансформаторное масло / Р. А. Липштейн, М. ?. Шахнович. – М. : Энергоатомиздат, 1983. – 296 с.

Михеев Г. М. Трансформаторное масло / Г. М. Михеев. – Чебоксары: ?зд-во Чуваш. ун-та, 2003. – 148 с.

Масла и смазки. Метод определения растворенной воды: ГОСТ 7822 - 75. – М.: ?ПК ?здательство стандартов, 2002.

Царев Н. ?. Практическая газовая хроматография / Н. ?. Царев, В. ?. Царев, ?. Б. Катраков. – Барнаул: ?зд-во Алт. ун-та, 2000. – 156 с.

Хмельницкий Р. А. Методы аналитической химии. Хромато-масс-спектроскопия / Р. А. Хмельницкий, Е. С. Бродский. – М.: Химия, 1984. –10 с.

Козлов В. К. Трансформаторное масло и современная физика / В. К. Козлов, А. Н. Туранов // Диэлектрики и электрическая изоляция. – 2012. – Т. 19, вып. 5. – С. 1485-1497.

Фрайден Дж. Современные датчики. Справочник / Дж. Фрайден. – М.: Техносфера, 2005. – 592 с.

Downloads

Published

2017-03-22

Issue

No. 4 (2016)

Section

Статті

License

Relationship between right holders and users shall be governed by the terms of the license Creative Commons  Attribution – non-commercial – Distribution On Same Conditions 4.0 international (CC BY-NC-SA 4.0):https://creativecommons.org/licenses/by-nc-sa/4.0/deed.uk

Authors who publish with this journal agree to the following terms:

  • Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
  • Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
  • Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).